ODOR-OX

Odor-Ox | Odor Control System



The Odor-Ox System destroys lift station and headworks odors.


The Odor-Ox System benefits:
____________________________
Reduced wet well corrosion
____________________________
Very low power requirements
____________________________
No reoccurring chemical cost
____________________________
Very quiet operation
 
 


Standard Features and Specs
____________________________
One year warranty
____________________________
Control panel built to UL 508A standards
____________________________
Incoming power surge arrestor (HT Model)
____________________________
Electrical requirements - 20A max at 120VAC
____________________________
Weatherproof low profile enclosure
____________________________
Color touch screen for monitoring system status, Historical trending, and selection of Automatic, Manual, or Timed oxidant production control. (HT Model)
____________________________
Oxygen concentration system
____________________________
10 - 100 GPH Ozone generator sizes
____________________________
Each control panel is thoroughly tested prior to shipment
Optional Features and Services
____________________________
Configuration for 208—480VAC applications
____________________________
Remote monitoring via SCADA or Cellular Modem
____________________________
Intrinsically safe process sensor circuit
____________________________
Auxiliary status and alarm contacts
____________________________
On-Site odor analysis
____________________________
On-Site system start-up and training
____________________________
Automatic closed loop control
____________________________
Extended warranty and lease programs available
____________________________
Stainless Steel or Aluminum enclosures
____________________________
Oda-Vac odor extraction fan
____________________________
Contact chamber




Odor-Ox | Field Test Results

The Odor-Ox Odor Control System is proven to destroy lift station odors.

A small water/waste water utility was having odor problems at a medium size lift station that was located in a nice neighborhood. A few years ago, they installed an air scrubber system designed to eliminate the odor. The scrubber was about 30 feet tall and used several pumps and fans to operate. After the system was installed, the odor complaints were reduced but the noise complaints increased dramatically. The system had to shut down at night to stop the noise complaints.

After a few years of expensive scrubber maintenance, they decided to try adding odor-control chemicals into the wet well. The chemicals helped reduce the odor complaints more than the scrubber. However, they were spending a large amount of money every month on chemical refills.

To help reduce the monthly cost of chemicals, they decided to try Odor-Ox. We analyzed the odor problem by measuring the amount of hydrogen sulfide emanating from the wet well. This information was used to help size the Odor-Ox system. The Odor-Ox system was packaged in a low profile non-metallic enclosure so that it could not be seen from the street. The installation utilized PVC pipe and one induced draft fan.

Once installed, the H2S was measured at the exhaust of the Odor-Ox system. The results are show below — Over 90% reduction in the concentration of hydrogen sulfide released into the surrounding area. Since Odor-Ox was commissioned, there have been no complaints about odor or noise.




Stop the complaining neighbor!

With the ODOR-OX ODOR CONTROL UNIT


3 SIZES TO FIT ALL NEEDS HT – LT & ECONOMY



Save on "costly" monthly chemical dripping

Easy To Install: No permits needed

No engineer required/120 volt "plug n play"

Quite and efficient
($150-200 per year)

Can be used as a POLISHER

All treatment is ABOVE wet well – NO CORROSION






Home  |   About Us  |   Products  |   Services  |   Case Studies  |   Contact Us




  Top of Page
© 2022 Gener-Ox™ Inc.